Porch Dweller's Wineador Progress

Porch Dweller · 08-25-2013, 01:08 PM

I decided that the heat and humidity here on the Gulf Coast warranted a little more protection for my smokes than just my humidors. As it's a few years before I'll be making the jump to an Aristocrat, I decided on a wineador.

I went with an 18-bottle NewAir. Why not 24? Because with all that extra space I'd be too tempted to fill it up.

I received the fridge a couple of days ago and gave it a wipe-down inside. Then I left the door open and kept a fan blowing into it overnight. In the morning, the "plasticy" smell was gone. I then put some electrical tape over the condensation drain hole as recommended by others here.

I'd ordered 1.5 lbs of HF beads and made a mistake - I should have just put them straight into the wineador along with a hygrometer, left them for a few hours, and seen where I needed to adjust from there. Instead, I partially wet them with some distilled water, let them sit for a bit, then put them in the wineador. They were WAY too saturated; the humidity shot up to 83%. I had to use a blow dryer to get rid of the excess.

I just now got the beads back in the wineador and plugged it in, temperature set at 65*. Cedar drawers have been ordered from cheaphumidors.com. Once I get them I'll post an update. Stay tuned...

big_jaygee · 08-25-2013, 01:18 PM

looks good so far James....have fun with this project and use it as a learning experience for when you buy the 28-bottle

Porch Dweller · 08-25-2013, 01:25 PM

Quote:

Originally Posted by big_jaygee

looks good so far James....have fun with this project and use it as a learning experience for when you buy the 28-bottle

Yeah, I'm in denial about the fact that I'm

big_jaygee · 08-25-2013, 01:28 PM

its a fun ride

i started small think i wouldn't fill up a 6-bottle, bought a 16-bottle two weeks later, again thinking i wouldn't fill it up....three weeks later i bought the 28-bottle.

.cigardude. · 08-25-2013, 01:40 PM

Good luck with the build buddy.

CigarNut · 08-25-2013, 02:18 PM

Very cool!

czerbe · 08-25-2013, 05:40 PM

Nice can't wait to see the build

Lockspur · 08-25-2013, 10:43 PM

Nice! You will love it.

4theLoveofCedar · 08-26-2013, 12:13 AM

Nice. I grew concerned with the heat in my apartment and got a wine fridge a couple months ago. I actually just stuck my 2 desktop humidors and 3 medium size Tupperwares directly into the fridge. It would definitely be nicer to have the fridge work as a humidor itself, but I was too lazy to try and figure out how to make that happen.

Porch Dweller · 08-26-2013, 05:46 AM

Quote:

Originally Posted by 4theLoveofCedar

Nice. I grew concerned with the heat in my apartment and got a wine fridge a couple months ago. I actually just stuck my 2 desktop humidors and 3 medium size Tupperwares directly into the fridge. It would definitely be nicer to have the fridge work as a humidor itself, but I was too lazy to try and figure out how to make that happen.

It's not very labor intensive and there are quite a few threads on here that lay out the process. For me, I'm making the move to a wineador simply for piece of mind.

Fordman4ever · 08-26-2013, 06:15 AM

Looks awesome, and mighty empty. You're a brave man.

Porch Dweller · 08-26-2013, 08:31 AM

Quote:

Originally Posted by Fordman4ever

Looks awesome, and mighty empty. You're a brave man.

LOL! I guess I should have noted that once it's ready, it will be filled with my existing stock. I forget that you've got to watch your step around here.

MrClean · 08-26-2013, 03:10 PM

Nice James, I think these are so cool looking as well as functional. I also think it's funny you believe the 16 bottle will prevent you from buying too much......good luck with that.

Porch Dweller · 08-26-2013, 03:19 PM

Quote:

Originally Posted by MrClean

Nice James, I think these are so cool looking as well as functional. I also think it's funny you believe the 16 bottle will prevent you from buying too much......good luck with that.

LOL! Yeah, space limitations hasn't kept me from buying more cigars than I have space for now, why would it with the wineador?

MUNKY · 08-26-2013, 10:42 PM

Awesome James, looks good! I am finally in the rh adjusting stage waiting on stuff to settle for mine!

ColdCuts · 08-26-2013, 11:47 PM

Nice, James. You're on your way. How're your numbers? If they're bouncing around, get some empty cedar boxes in there to help level her out. Also, you might want to stick a tiny fan in there at some point. Are you having any issues with condensation?

Looking forward to watching your project unfold.

Porch Dweller · 08-27-2013, 07:39 AM

Quote:

Originally Posted by ColdCuts

Nice, James. You're on your way. How're your numbers? If they're bouncing around, get some empty cedar boxes in there to help level her out. Also, you might want to stick a tiny fan in there at some point. Are you having any issues with condensation?

Looking forward to watching your project unfold.

I've got a few empty boxes in there now to help stabilize the RH. The shelves should be here tomorrow so they'll help get me where I need to be.

I plan on having a hygrometer at the top and at the bottom. If I notice a difference of more than two or three in the RH I'm going to look into getting a small computer fan to put in the bottom. My preferred method would be to have it on a timer, running about 10-15 minutes every two hours or so.

No condensation so far.

Here it is with the only empty boxes I had on hand inside it:

RH has been right around 70 for 24 hours. After I get the shelves in it tomorrow I'll give it another 24 hours to see if I need to adjust the beads.

Bondo 287 · 08-27-2013, 08:38 AM

Quote:

Originally Posted by Porch Dweller

.....
I plan on having a hygrometer at the top and at the bottom. If I notice a difference of more than two or three in the RH I'm going to look into getting a small computer fan to put in the bottom. My preferred method would be to have it on a timer, running about 10-15 minutes every two hours or so.

No condensation so far.
.....

Hi Porch !
I just got a Haier model HVW18 last weekend. I did not want to go to wineador so fast, but it was a display unit and practically free. It is absolutely pristine with excellent seal. But it needed service from apparently running constantly on display. So it appears a thermostat circuit error was it's demise. I cleaned the external heat sinks ( no compressor) and I already had new PC fans on hand to replace the dead ones yesterday.

I could likely have replaced the thermostat control board but instead I just " dumbed it down" .
So I'll be interested in what type of timer you use, so I can run a similar cycle.

Wharf Rat · 08-27-2013, 06:01 PM

Quote:

Originally Posted by Bondo 287

Hi Porch !
I just got a Haier model HVW18 last weekend. I did not want to go to wineador so fast, but it was a display unit and practically free. It is absolutely pristine with excellent seal. But it needed service from apparently running constantly on display. So it appears a thermostat circuit error was it's demise. I cleaned the external heat sinks ( no compressor) and I already had new PC fans on hand to replace the dead ones yesterday.

I could likely have replaced the thermostat control board but instead I just " dumbed it down" .
So I'll be interested in what type of timer you use, so I can run a similar cycle.

I don't have a circuit diagram. But, you may need that circuit board to power the cooling modules.

ColdCuts · 08-27-2013, 10:51 PM

Quote:

Originally Posted by Wharf Rat

I don't have a circuit diagram. But, you may need that circuit board to power the cooling modules.

I sincerely wish I knew what you guys are talking about. I'm sure I'd have a better job today. Instead, I went to art school. What was I thinking?! Ugh. My old man was right!

This is why I use an Oust fan. It's got an on/off switch, runs on one "D" battery, automatically toggles on/off every now and again, is perfectly silent, and I think I picked it up for $8 about seven or so years ago.

It still works great and keeps my cigars resting comfortably.

08-25-2013, 01:08 PM	#1
Porch Dweller Life is for living Join Date: Oct 2012 First Name: James Location: Mississippi Gulf Coast Posts: 8,461 Trading: (24)	Porch Dweller's Wineador Progress I decided that the heat and humidity here on the Gulf Coast warranted a little more protection for my smokes than just my humidors. As it's a few years before I'll be making the jump to an Aristocrat, I decided on a wineador. I went with an 18-bottle NewAir. Why not 24? Because with all that extra space I'd be too tempted to fill it up. I received the fridge a couple of days ago and gave it a wipe-down inside. Then I left the door open and kept a fan blowing into it overnight. In the morning, the "plasticy" smell was gone. I then put some electrical tape over the condensation drain hole as recommended by others here. I'd ordered 1.5 lbs of HF beads and made a mistake - I should have just put them straight into the wineador along with a hygrometer, left them for a few hours, and seen where I needed to adjust from there. Instead, I partially wet them with some distilled water, let them sit for a bit, then put them in the wineador. They were WAY too saturated; the humidity shot up to 83%. I had to use a blow dryer to get rid of the excess. I just now got the beads back in the wineador and plugged it in, temperature set at 65. Cedar drawers have been ordered from cheaphumidors.com. Once I get them I'll post an update. Stay tuned... __________________ A 1911 in the hand is faster than 911 on the phone*

08-25-2013, 01:18 PM	#2
big_jaygee I'm nuts for the place Join Date: Dec 2012 First Name: Jason Location: Houston Posts: 3,914 Trading: (59)	Re: Porch Dweller's Wineador Progress looks good so far James....have fun with this project and use it as a learning experience for when you buy the 28-bottle

08-25-2013, 01:28 PM	#4
big_jaygee I'm nuts for the place Join Date: Dec 2012 First Name: Jason Location: Houston Posts: 3,914 Trading: (59)	Re: Porch Dweller's Wineador Progress its a fun ride i started small think i wouldn't fill up a 6-bottle, bought a 16-bottle two weeks later, again thinking i wouldn't fill it up....three weeks later i bought the 28-bottle.

08-25-2013, 01:40 PM	#5
.cigardude. Still Watching My Back Join Date: Jul 2013 Location: Miami, FL. Posts: 171 Trading: (0)	Re: Porch Dweller's Wineador Progress Good luck with the build buddy.

08-25-2013, 02:18 PM	#6
CigarNut Fck Cancer! Join Date: Jan 2009 First Name: Michael Location: Clermont, Florida Posts: 18,042 Trading: (111*)	Re: Porch Dweller's Wineador Progress Very cool! __________________ Need Beads? Need Five Finger Bags? 2 of 3 Requirements for use of the CA Rolodex: 100 posts/ 60 day membership/ participation in trade (trader rating). New members can be added at any time.

08-25-2013, 05:40 PM	#7
czerbe Just a Traveling Man Join Date: Apr 2012 First Name: Corey Location: Reading Pa Posts: 1,309 Trading: (2)	Re: Porch Dweller's Wineador Progress Nice can't wait to see the build __________________ Live fast, hard, everyday like its your last.

08-25-2013, 10:43 PM	#8
Lockspur Have My Own Room Join Date: Dec 2012 First Name: Scotty Location: Richmond, TX Posts: 1,376 Trading: (31)	Re: Porch Dweller's Wineador Progress Nice! You will love it. __________________ Proud member of the GMCGTPWHAFA

08-26-2013, 12:13 AM	#9
4theLoveofCedar Burn and Turn Join Date: Aug 2013 Location: San Francisco Bay Area Posts: 25 Trading: (0)	Re: Porch Dweller's Wineador Progress Nice. I grew concerned with the heat in my apartment and got a wine fridge a couple months ago. I actually just stuck my 2 desktop humidors and 3 medium size Tupperwares directly into the fridge. It would definitely be nicer to have the fridge work as a humidor itself, but I was too lazy to try and figure out how to make that happen.

08-26-2013, 06:15 AM	#11
Fordman4ever Redneck driving a ricer!! Join Date: Dec 2010 First Name: Earl Location: A place too cold to smoke outside Posts: 2,508 Trading: (26)	Re: Porch Dweller's Wineador Progress Looks awesome, and mighty empty. You're a brave man. __________________

08-26-2013, 03:10 PM	#13
MrClean Bald Man Join Date: Sep 2011 First Name: Jeff Location: KC MO Posts: 2,229 Trading: (28)	Re: Porch Dweller's Wineador Progress Nice James, I think these are so cool looking as well as functional. I also think it's funny you believe the 16 bottle will prevent you from buying too much......good luck with that. __________________ http://jeffcarrollphotos.com Not a photographer, just a dude with a camera. Proud member of the GMCGTPWHAFA

08-26-2013, 10:42 PM	#15
MUNKY Resident Pig Hunter Join Date: May 2013 First Name: Brandon Location: Pearland, TX Posts: 1,169 Trading: (19)	Re: Porch Dweller's Wineador Progress Awesome James, looks good! I am finally in the rh adjusting stage waiting on stuff to settle for mine! __________________ Proud member of the GMCGTPWHAFA

08-26-2013, 11:47 PM	#16
ColdCuts Adjusting to the Life Join Date: Aug 2009 First Name: Dave Location: Queens, NY Posts: 375 Trading: (10)	Re: Porch Dweller's Wineador Progress Nice, James. You're on your way. How're your numbers? If they're bouncing around, get some empty cedar boxes in there to help level her out. Also, you might want to stick a tiny fan in there at some point. Are you having any issues with condensation? Looking forward to watching your project unfold. __________________